The effect of adding berry fruit juice concentrates and by-product extract to sugar solution on osmotic dehydration and sensory properties of apples

摘要

Osmotic dehydration (OD) of apples caused a reduction of normalized water content (NWC) and an increase of normalized solids gain (NSG), independently of the kind of osmotic solution. The use of 22°Brix osmotic solutions with the addition of fruit concentrates or bilberry extract resulted in only slight reduction in the NWC in the samples, i.e. by about 15 and 20%, respectively after 6 and 24 h, against a value up to 80% in case of 65°Brix use. Similarly, larger NSG was achieved at higher solution concentrations, but the differences were smaller. In the case of the use of 80% bilberry press cake extract the NSG was very low but NWC was relatively high. Such a low concentration of slightly concentrated fruit juices is not effective for dehydration of apples, but it may be sufficient to enrich the fruit with the desired colorants. This higher concentration of osmotic solution and a larger addition, especially of the concentrate of chokeberry juice, significantly affected the color changes of dehydrated apples. The apple dehydrated in mixture of 65°Brix sucrose and 15% chokeberry juice concentrate solution exhibited the highest sensory parameters. The addition of berry fruit juices and extract was able to improve the apple sensory quality after 24 h OD in comparison with sucrose solution. Ethanol extract was a good osmotic agent, but not accepted due to taste and overall quality. However, the addition of the extract can be successfully used in conjunction with a sugar solution.