Water purification of aqueous nickel sulfate solutions by air cooled natural freezing

摘要

Ni2+ in excess of maximum recommended limits must be removed from wastewater prior to discharge because of its persistent bio-accumulative and detrimental nature. Natural freezing is suggested as a purification technique to treat huge volumes of wastewater containing Ni2+ in a sustainable and energy efficient manner. In order to evaluate the feasibility of such a technique for purification of wastewater, natural freezing was simulated experimentally for ice crystallization from different NiSO4 (aq) solutions. The impact of solution concentration at different freezing conditions such as different ambient air temperature, freezing time and freezing rate on the efficiency of the purification process was investigated. Experimental results demonstrated that at the growth rate (G) of 3.5 x 10(-8) m/s, the ice layer formed from 1 wt.% (approximate to 1 0,000 ppm) NiSO4 (aq) solution incorporated only 0.0038 wt.% (approximate to 38 ppm) NiSO4 as impurity, i.e., the ice is more than 250 times pure than the original salt solution. In the case of freezing of very dilute solutions, e.g., 0.1 wt.% NiSO4 (aq) solution, which is the dilution level of practical interest, the same growth condition is likely to produce an ice layer of even higher purity. For example, at G of 7.4 x 10(-8) m/s, the ice layer impurity that had formed from 0.1 wt.% NiSO4 (aq) solution was only 0.001 wt.% (approximate to 10 ppm). For this reason, this purification technique has potential for implementation on the surface of wastewater ponds in cold climate regions where the temperature drops below 0 degrees C. In addition, inclusion formation within the ice matrix during freezing was investigated for various solution concentrations both macroscopically and microscopically. (C) 2016 Elsevier B.V. All rights reserved.