Integrated Treatment Processes For Primary Wool Scouring Effluent

摘要

The increasing cost of effluent treatment in the wool scouring industry is rapidly becoming a determining factor in the viability of existing scouring operations and new installations alike. This thesis details the development of an integrated effluent treatment process capable of treating the worst polluted effluent from a wool scour "heavy flow-down", to the point where it can either be economically discharged to local trade waste sewer, or directly discharged to river or ocean outfall with minimal environmental impact. The existing proprietary chemical flocculation process, Sirolan CF™, was improved by the addition of a bio-flocculation stage and turbidity monitoring and control, and the product from this process fed to an aerobic biological treatment system based upon the traditional activated sludge process. The biological treatment process was found to remove up to 98% of the BOD5 loading from the pre-treated liquor with a hydraulic residence time of at least 50 hours being required in the aerobic digestion vessels. A residual biorefractory COD of approximately 3,600mg/L was identified which could not be removed by biological treatment. When operating continuously, the biological process was observed to metabolically neutralise the pH 3.0 - 4.5 feed from the chemical flocculation system to pH 7.0 without the need for supplemental addition of neutralising agents such as sodium hydroxide. This in itself provides a significant economic incentive for implementation of the process. Kinetic analysis of the biological process carried out under controlled laboratory conditions using a Bioflo 3000 continuous fermentor showed that the bio-chemical process followed substrate inhibition kinetics. An appropriate kinetic model was identified to represent the behaviour of the substrate degradation system, and modified by inclusion of a pseudo toxic concentration to account for the effect of pH inhibition upon the biological growth rate. The process was verified both at pilot plant scale and at demonstration plant scale at an operational wool scour. The demonstration plant was of sufficient size to handle the full heavy effluent flow-down from a small wool scour. At the time of publishing three full-scale effluent treatment systems based on this research had been sold to both domestic and international clients of ADM Group Ltd. who funded the research.