Very high expander processing of maize on animal performance, digestibility and product quality of finishing pigs and broilers

摘要

The present study investigated the effect of hydrothermic maize processing and supplementation of amino acids (AA) in two experiments. In total, 60 barrows and 384 broilers were fed four diets including either unprocessed (T1), or hydrothermically processed maize, that is short- (T2), or long-term conditioned (LC) (T3), and subsequently expanded maize of the same batch. Assuming a higher metabolizable energy (ME) content after processing, the fourth diet (T4) contains maize processed as treatment T3, but AA were supplemented to maintain the ideal protein value. Performance, digestibility and product quality in both species were assessed. Results show that in pigs receiving T4 the average daily feed intake was lower compared with the other treatments, whereas no difference was observed in broilers. The T3 improved the feed conversion rate compared with T1 (P0.10) for both species. In contrast, average daily gain (ADG) (1277 g/day for T2 and 1267 g/day for T3 v. 971 g/day for T1) was only altered in pigs. The hydrothermic maize processing increased the apparent total tract digestibility (ATTD) of dry matter, starch and ether extract after acid hydrolysis. This may be a consequence of higher ATTD of gross energy in the finishing phase for both animal species, suggesting a higher ME content in diets with processed maize. The higher ME content of diets with processed maize is supported also by measurements of product quality. Supplementation of AA in T4 enhanced the loin depth in pigs as well as the amount of breast meat in broilers. Further effects of processing maize on meat quality were the reduced yellowness and antioxidative capacity (P0.10) for broilers, likely due to the heat damage of xanthophylls and tocopherols. Processing also increased springiness and chewiness (P0.10) of the broilers breast meat, whereas the loin meat of pigs showed a decreased lightness and yellowness (P0.10) in meat when hydrothermic processed maize was used (for T2, T3 and T4). LC processed maize (T3) showed the lowest springiness in pork, however the supplementation of AA in T4 did not show differences between the treatments. Shown results demonstrated positive effects of hydrothermic processing of maize on animal performance and digestibility in both species. However, effects on carcass characteristics and product quality differed. The negative effects on product quality could be partly compensated with the AA supplementation, whereas a change in meat colour and reduced antioxidative capacity was observed in all groups fed hydrothermic maize processing.