转鼓和搅拌槽反应器中氧化亚铁硫杆菌氧化Fe2+的比较

摘要

研究转鼓和搅拌槽反应器中氧化亚铁硫杆菌在不同Al2O3粉末含量下对Fe2+的氧化.结果表明:未添加Al2O3粉末时,氧化亚铁硫杆菌在搅拌槽中的生物活性比在转鼓中的生物活性高.当Al2O3粉末含量从0增加到50％(质量分数)时,Fe2+的生物氧化速率从0.23 g/(L·h)显著降低到0.025 g/(L·h),可能是搅拌槽中的固体颗粒碰撞和研磨作用导致氧化亚铁硫杆菌失活.转鼓中Al2O3的含量增加对氧化亚铁硫杆菌的生物活性仅有较小的负面影响,这是由于两个反应器不同的混合机制所致.在相同的Al2O3含量下,Fe2+在转鼓反应器中的生物氧化速率比在搅拌槽中的生物氧化速率更高,尤其在较高的固体含量下,表明转鼓反应器能允许较高的固体含量和维持较高的生物活性.由于Al2O3粉末与真实硫化矿具有不同的物理化学性质,因此转鼓反应器用于硫化矿生物浸出的可行性还需进一步验证.%Fe2+ oxidation by Acidithiobacillusferrooxidans (At.ferrooxidans) under different solid contents by adding inert Al2O3 powder was examined in rotating-drum and stirred-tank reactors.The results show that the bioactivity of At.ferrooxidans in the stirred-tank is higher than that in the rotating-drum in the absence of Al2O3 powder,but the biooxidation rate of Fe2+ decreases markedly from 0.23 g/(L·h) to 0.025 g/(L·h) with increasing the content of Al2O3 powder from 0 to 50％ (mass fraction) in the stirredtank probably due to the deactivation of At.ferrooxidans resulting from the collision and friction of solid particles.The increase in Al2O3 content has a little adverse effect on the bioactivity of At.ferrooxidans in the rotating-drum due to different mixing mechanisms of the two reactors.The biooxidation rate of Fe2+ in the rotating-drum is higher than that in the stirred-tank at the same content of Al2O3 powder,especially at high solid content.The higher bioactivity of At.ferrooxidans can be maintained for allowing high solid content in the rotating-drum reactor,but its application potential still needs to be verified further by the sulfide bioleaching for the property differences of Al2O3 powder and sulfide minerals.