Anaerobic biodegradation of soybean-process wastewater: Operation strategy and sludge bed characteristics of a high-performance Spiral Symmetric Stream Anaerobic Bioreactor

摘要

A 300m(3)/d demonstration project of soybean-process wastewater has been established recently with a Spiral Symmetric Stream Anaerobic Bioreactor (SSSAB) as the core. In order to obtain the optimal operation strategy for a full-scale SSSAB and to make it run efficiently and stably in a demonstration project, a Pilot-scale SSSAB (P-SSSAB, effective volume 100 L) was performed for the treatment of soybeanprocess wastewater over 216 days. The volumetric load rate (VLR) range of the P-SSSAB was 0.32 similar to 27.17 kg COD/(m(3).d), where the highest VLR [27.17 kg COD/(m(3).d)] was 2.01 times to the highest value [13.5 kg COD/(m(3).d)] reported. The pH and VFA/ALK of the effluent from the P-SSSAB were in the range of 6.9 up to 9.2 and 0.03 up to 0.17, respectively. The methane yield of the P-SSSAB increased from 0.03 m(3) /kg COD to 0.47 m(3)/kg COD, which was 3.36 times to the maximum value (0.14 m(3) /kg COD) reported. To meet the influent requirement of the aerobic biological treatment in demonstration project (influent COD = 1.5 g/L), the maximum VLR of SSSAB was optimal at about 22 kg COD/(m(3).d). By analyzing the sludge bed characteristics of the P-SSSAB, it was obvious that zone I (the bottom of the bed) was the major contributor of the COD removal, while zone III (the upper part of the bed) was the major contributor for the NH4+-N increase. The anaerobic granular sludge (AGS) in the bed showed a good granulation. The average MLVSS/MLSS value in sludge bed was about 0.7, and PN/PS in TB-EPS (zone I, II and III) increased to 6.830, 4.257, and 3.747, respectively. SMA and coenzyme F 420 values of zone III were the maximum [666.35 ml CH4/(g VSS.d) and 0.690 mol/g VSS, respectively]. According to the analysis obtained from the 16S rRNA high-throughput sequencing, the microbial community in the AGS had been more specific to the soybean-process wastewater since the bacteria Firmicutes were increased. The relative abundance of microbe which perform direct interspecies electron transfer (DIET) for the syntrophic degradation of VFAs and production of the methane has been increased significantly, such as the bacteria Syntrophomonas and archaea Methanosaeta. (C) 2021 Elsevier Ltd. All rights reserved.