首页> 中文期刊>高校化学工程学报 >采用电阻层析成像技术测量气液加压鼓泡塔局部气泡参数

采用电阻层析成像技术测量气液加压鼓泡塔局部气泡参数

     

摘要

在内径0.3 m,高6.6 m的加压气液鼓泡塔反应器中,采用电阻层析成像技术(ERT)研究了空气-水体系中气泡群平均上升速度、局部气含率及其径向分布。在表观气速0.119~0.312 m⋅s−1,压力0.5~2.0 MPa,考察了表观气速、压力对气泡群上升速度、局部气含率及其径向分布的影响。实验结果表明,鼓泡塔中局部气含率随着表观气速与压力的增大而增大,其径向分布呈现出中心高边壁低的分布特征,但整个截面的分布并非严格对称,在 r/R=0~0.3,气含率变化较小,且极大值出现在该范围内;气泡群的局部上升速度随着表观气速的增大而增大,但是随着压力的增大而减小。%  Mean bubble swarm rising velocity and radial variation of gas holdup were investigated by using electrical resistance tomography (ERT) in a bubble column reactor with 0.3 m diameter and 6.6 m height under elevated pressures. In all the experiments, air was used as the gas phase and tap water as liquid phase where the gas velocity was varied from 0.119 to 0.312 m⋅s−1 and the system pressures was varied from 0.5 to 2.0 MPa. The effects of operation conditions on the radial distribution of gas holdup and bubble swarm rising velocity were discussed. The results show that the gas holdup increases constantly with the increase of the superficial gas velocity and pressures, and there is a maximum holdup in the range of r/R=0~0.3, at the same time, the radial distribution of gas holdup is flatter in this region. However, as the gas holdup, the bubble swarm rising velocity increases constantly with the increase of the superficial gas velocity, but decreases with the increase of pressures.

著录项

相似文献

  • 中文文献
  • 外文文献
  • 专利
获取原文

客服邮箱:kefu@zhangqiaokeyan.com

京公网安备:11010802029741号 ICP备案号:京ICP备15016152号-6 六维联合信息科技 (北京) 有限公司©版权所有
  • 客服微信

  • 服务号