A wide range of outcrop sandstones and carbonates have been tested for waterflood response to one twentieth dilution of synthetic seawater, using a single crude oil that gave high response to low salinity flooding for a reservoir rock. The tested outcrop rocks included 17 sandstones and 6 carbonates. Gas permeabilities ranged from 1.49 to 7,187 mD and porosities from 10 to 39%. The average reduction in residual oil for tertiary response was only 1.5% OOIP with the highest being 5.8% OOIP; some rocks showed no response. After testing, three of the outcrop rocks that responded to injection of low salinity brine were restored by cleaning and re-aging with crude oil using procedures comparable to those commonly used in restoration of reservoir cores. When re-tested, the response to low salinity flooding was eliminated for two of the cores and significantly reduced for the third core. Companion plugs for 6 of the sandstones and 3 carbonates were tested for increased oil recovery using low salinity connate and injected brine; this data provided comparison with the measurements for high salinity connate and injection brine. Six of the plugs showed increase in recovery for the low salinity waterfloods, and three showed decrease. Results are also summarized for the effects of reduction in salinity for 11 sandstone cores taken from five reservoirs and 8 carbonate cores all taken from the same reservoir. Comparison between results for outcrop and reservoir cores, including literature data, indicates that overall response to low salinity flooding is significantly higher for the reservoir cores.
展开▼
