Development of a new hazelnut sandwich ELISA based on detection of Cor a 9, a major hazelnut allergen

摘要

The emerging health problem of food-induced allergic reactions, including life-threatening anaphylaxis, presents an important challenge to the food. In the framework of the current ALLERRISK project, analytical approaches for allergen detection are evaluated and developed. Cor a 9 is a major hazelnut protein with nutrient reservoir function, and that also known as a major food allergen. Presence of Cor a 9 indicates contamination of a product with hazelnut and, consequently, potential risk of allergenicity.Crude extract of hazelnut was obtained from milled mixture of hazelnuts from 10 commercially available brands. Then the extract was concentrated and applied to gel filtration and Con A affinity chromatography columns for Cor a 9 isolation and purification. The final product was characterized by analytical gel permeation chromatography, SDS PAGE and MALDI mass spectrometry. The purified Cor a 9 was used as an antigen for the production of polyclonal antibodies in chickens according to the protocol developed in our laboratory. A part of the most active antibodies was further purified by gel permeation chromatography and characterized by SDS PAGE before further use. The prepared antibodies were applied for development of a sandwich ELISA using polyclonal antibody-enzyme adducts as a tracer. Optimization of reagent concentrations led us to achieve detection limit ~10 ng/ml. Influence of ionic strength, pH and buffer composition on analytical parameters of the developed ELISA were thoroughly studied. The developed ELISA can be successfully applied for quantitative detection of Cor a 9 in large pH (pH = 5 – 10) and ionic strength (0.05 – 1.5 M salts solution) ranges. Cross-reactivity with series of nuts, ovalbumin, whey, and wheat proteins was also investigated (Figure 2) and showed that the developed assay was very specific. Moreover, presence of several other proteins (peanut, cashew, ovalbumin, whey and wheat) at high concentrations (1 mg/ml) in the presence of Cor a 9 did not influence the calibration curve of Cor a 9. Detection of hazelnut protein in cookies with known amount of hazelnut inside initial dough showed good recovery (35-40%) and absence of significant signal in blank samples (i.e. without spiking of hazelnut).