THE EFFECT OF COAL TYPE, RESIDENCE TIME AND COMBUSTION CONFIGURATION ON THE SUBMICRON AEROSOL COMPOSITION AND SIZE DISTRIBUTION FROM PULVERIZED COAL COMBUSTION (STAGED, FLYASH, SPECIES ENRICHMENT).

摘要

Pulverized samples of Utah bituminous, Beulah (North Dakota) low Na lignite, Beulah high Na lignite and Texas (San Miguel) lignite coals were burned at a rate of 2.5 kg/hr in a laboratory furnace under various (overall fuel lean) combustion conditions. Particle size distributions (PSD) and size segregated particle filter samples were taken at various positions within the convection section. Temperature and gas concentrations were measured throughout. The evolution of the submicron PSD within the convection section for the four coals was similar, although the location of the initial particle mode at the convection section inlet varied with coal type. While staged (.8/1.2) combustion of the Utah bituminous coal had a variable effect on the volume of submicron aerosol produced, staged combustion of two of the three lignites (Beulah low Na and Texas) caused a definite increase in the submicron aerosol volume. Vapor enhancement due to a localized reducing atmosphere, which would effect coals of higher ash volatility or higher inherent ash content, is thought to explain this behavior. Depressed combustion temperatures associated with the high moisture content of the Beulah high Na lignite are thought to offset the effects of staging. Increased combustion temperatures (through oxygen enrichment) caused staged volume increases for the Beulah high Na lignite. Combustion temperatures are a controlling factor even at more extreme staging conditions. Chemical analysis of the size segregated particle samples show the trace elements, As, Pb, Zn and the major elements, Na and K to be enriched in the submicron aerosol. Auger depth profiles show these small particles to be comprised of a core enriched in Fe, Si, Ca and Mg and surface layers enriched in Na and K. These results point to a mechanism of homogeneous nucleation of low vapor pressure species followed by successive layering of progressively more volatile species. Volatile species are enriched in the submicron aerosol due to the large surface areas provided. Modeling efforts show that while coagulation may be the dominant mechanism to describe the aerosol evolving within the convection section, it cannot be used solely to predict the PSD. Another mechanism, presumably surface area dependent growth (condensation) must be included.