Measurements of two-dimensional distribution of refrigerant concentration in EHL film using micro FT-IR and effect of variation of concentration on oil film thickness

摘要

The dissolution of refrigerant into a lubricant causes a decrease in viscosity of the oil and it gives a large effect on the lubrication of sliding parts in a refrigerant compressor. This paper describes an application of micro FT-IR to measure the two-dimensional concentration distribution of refrigerant held in solution in the EHL film surrounded by the refrigerant gas and discusses the refrigerant concentration variation in the vicinity of the Hertzian contact area. In order to measure the concentration distribution, an apparatus which can observe the EHL film in a point contact in the refrigerant atmosphere was developed. The refrigerant concentration was measured using micro FT-IR through a CaF{sub}2 window from outside of the apparatus with polyol ester as a base oil in an atmosphere pressurized with HFC-134a refrigerant gas. The results indicate that the concentration of HFC-134a refrigerant reduces in the inlet boost region of EHL contact and the Hertzian contact area but in the side region of Hertzian contact area it is greater than that in the bulk fluid. In addition, the effect of the variation on the oil film thickness is discussed.